Produced Water Pretreatment Prior to Filtration with Forward Osmosis and Membrane Distillation Integrated System
Permanent link to this recordhttp://hdl.handle.net/10754/670251
MetadataShow full item record
AbstractThe simultaneous treatment of different produced water streams with the forward osmosis membrane distillation hybrid system (FO-MD) has been suggested recently. This work investigates the need for pretreatment of produced water prior to filtration with FO-MD in order to reduce the level of fouling and scaling in the system. The desalter effluent (DE) stream was selected as FO feed solution, and the water oil separator (WO) stream was used as FO draw solution/MD feed solution, and a significant flux decline was observed in FO and MD within the first 5 hours of operations. SEM and EDX analysis indicated that the formation of scale layer on both membranes was the main reason for the sharp flux decline. Silica was the major contributor to the scaling of the support layer of the FO membrane. While the scaling layer on MD membrane consisted mainly of CaSO4 crystals with some deposition of Silica. Therefore, electrocoagulation (EC) was selected for the pretreatment of produced water to target the removal of Ca, SiO2 and SO4 ions in order to reduce the likelihood of inorganic fouling in FO-MD. The different parameters of EC, namely, the current density, electrolysis time, and initial pH were tested at a wide range of values of 7-70 mA/cm2 , 10-60 minutes, 5-9, respectively. calcium and sulfate ions were not effectively removed at the relatively high applied current density of 70 mA/cm2 , while high removal of silica was achieved even at low applied current densities. The optimum conditions of EC for silica removal were found to be 7 mA/cm2 for the current density and 10 minutes for the electrolysis time which resulted in a 97% removal of silica. it was found that due to pretreatment, the average FO and MD fluxes increased by 49% (9.93 LMH) and 39% (8.55 LMH), respectively. Therefore, even though EC did not show promising results in terms of the removal of calcium and sulfate, efficient silica removal was achieved with minimum energy requirements which suggests that it could have a potential to be integrated with the FO-MD hybrid system for the treatment and reclamation of produced water.
CitationAlqulayti, A. (2021). Produced Water Pretreatment Prior to Filtration with Forward Osmosis and Membrane Distillation Integrated System. KAUST Research Repository. https://doi.org/10.25781/KAUST-7Q6U1